Hello,
As a new-comer, apologies in advance if I'm posting in the wrong category or have overlooked existing answers to this common occurrence.
L319 2008 Discovery 3 SE 2.7 TDV6 115k, RHD, manual, average service history.
I see a cloud of blackish smoke on acceleration.1st and 2nd seem quite sluggish, lots of torque 3rd-5th on the flat, cruises well in 6th but on hills I'm shifting through the box (manual) and feel the power is down (although I've nothing to compare it to). There is a slight whistling, appearing to originate from the driver's side behind the console present on acceleration, especially in 3rd gear, and also sometimes when coming off the gas. Possibly unrelated but just in case - the cabin smells quite strongly of exhaust fumes (from air circulation vents) - FBH is inoperative [something for another day - U0073-08 (2E), B1D34-68 (2F), U0164-87 (2E), U1A44-6C (2E), U3000-55 (2E].
I cleaned the MAF sensor, replaced the air filter and blanked the EGR (also removed butterfly valve)... the latter at -12C in a foot of snow on the driveway. The (large) intercooler hose appears okay with no obvious splits or holes. Under harder acceleration, I get an Engine System Fault message (clears on cycling the ignition, but comes back again) but no EMS light or limp mode.
The following faults were visible (and a bunch of others due to unrelated systems):
P023D-22 (68) Manifold absolute pressure - turbocharger/supercharger boost sensor A correlation - General signal failure - signal amplitude>maximum
P0101-17 (68) Mass or volume air flow - circuit range/performance - General electrical failure - circuit voltage above threshold
Any thoughts on this?
Thank you
Dom
2.7 TDV6 Black Smoke Underpowered MAF MAP
- anglefire
- Site Admin
- Posts: 19327
- Joined: Sat May 15, 2010 8:01 pm
- Winner: Club Member of Year 2012 & 13
- Car Details: Skoda Enyaq IV 80
- Member Since: 17 May 2010
- Location: Solihull, West Midlands
- Contact:
Re: 2.7 TDV6 Black Smoke Underpowered MAF MAP
Bodsy - Ian Bodsworth the Chairman is one person that would probably have a good idea.
EGR's are the obvious thing, but you've blanked them - however, the 08 might also need the ECU recoded to remove it from the mapping - Bodsy can help with that too.
Cabin smelling of exhaust is not good- has the gearbox been out recently as that could be the crossover pipe cracked and its a bitch to refit if the box has come out underneath.
EGR's are the obvious thing, but you've blanked them - however, the 08 might also need the ECU recoded to remove it from the mapping - Bodsy can help with that too.
Cabin smelling of exhaust is not good- has the gearbox been out recently as that could be the crossover pipe cracked and its a bitch to refit if the box has come out underneath.
Mark
Waeco CFX 40
1977 Triumph Spitfire 1500
Skoda Enyaq IV 80
Skoda Superb SE L Ex (Gone)
2006 disco3 SE. Gone but not forgotten.
BMW 530d M Sport Touring. Gone
Member of Admin team and
Disco3Club Photos: Here
Waeco CFX 40
1977 Triumph Spitfire 1500
Skoda Enyaq IV 80
Skoda Superb SE L Ex (Gone)
2006 disco3 SE. Gone but not forgotten.
BMW 530d M Sport Touring. Gone
Member of Admin team and
Disco3Club Photos: Here
Re: 2.7 TDV6 Black Smoke Underpowered MAF MAP
Thanks for the steer. The gearbox hasn’t been out but the crossover might be something to look into. I’ll not have a chance to do any investigation over the next couple of weeks but will update the thread if there are any developments.
Re: 2.7 TDV6 Black Smoke Underpowered MAF MAP
Yes and no... The problem was found to be the crossover pipe, which had split. The "repair" is still pending, however.
Cheers!
Cheers!